Product ID:TONER, E-D57
MSDS Date:02/22/1994
FSC:6850
NIIN:00N069397
MSDS Number: CBKKC

MINOLTA CAMERA CO LTD

3-13, 2-CHOME AZUCHI-MACHI CHUO-KU
OSAKA, 541, JAPAN

Emergency Phone: 05-271-2251

Info Phone: 05-271-2251

Cage: S4049

MINOLTA CAMERA CO LTD

HIGASHI-KU OSAKA 541

Telephone: 05-271-2251

Cage: S4049

POLYESTER RESIN

CAS: 109909-27-5

Fraction By Weight: >85%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-3%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-0

RTECS: TR5000000

Fraction By Weight: 1-3%

OSHA PEL N/K

ACGIH TLV: N/K

AMORPHOUS SILICA

CAS: 7631-86-9

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:LD50:(ORAL,RAT) >5.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NONTOXIC DUST. MAY CAUSE COUGH AND RAISE PHLEGM. TONER PRESENTS LOW
HAZ FOR USUAL OCCUP SETTINGS. BASED ON AVAIL DATA, HUMAN EXPOS TO
TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR
W/LG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:AMTS OF ANY NON-TOXIC DUSTS. RESULTS
OF ONE ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS TEN TIMES
MORE RESPIRABLE THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE
NO LUNG CHANGES @ LOW EXPOS(MOST RELEVANT LEV TO POTNTL
HUMANEXPOS). AT HIGHER LEV A SLIGHT DEGREE OF LUNG FIBROSIS WAS
OBSERVED DUE (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:WASH NOSTRILS, RINSE MOUTH. INGEST:DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER. EYES:FLUSH W/WATER FOR @
LEAST 15 MINUTES. SKIN:WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:IF DISPERSED IN AIR, TONER, LIKE MOST
FINELY DIVIDED ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQD WHEN USED AS INTENDED. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED WHEN USED AS INTENDED.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:TO EXCESS AMTS OF DUST RETAINED IN LUNGS FOR PRLNGD
INTERVAL.

Spec Gravity:1.2 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:WASTE MAY BE DISPOSED OR INCINERATED UNDER
CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.